BEUDAMED
    FDA Adverse Event Injury Summary report: N

    SIGMA CR150 CEM SZ 3 RT

    MDR report key: 10600980 · Received September 29, 2020

    Report

    Report Number
    1818910-2020-21111
    Event Type
    Injury
    Date Received
    September 29, 2020
    Report Date
    September 16, 2020
    Manufacturer
    DEPUY INTERNATIONAL LTD - 8010379
    Product Code
    JWH
    UDI-DI
    10603295074953
    PMA / PMN Number
    K082500
    Adverse Event
    Yes
    Report Source
    Manufacturer report
    Reporter Location
    US
    Reporter Occupation
    OTHER

    Narratives

    Additional Manufacturer Narrative · 0

    PRODUCT COMPLAINT # ==> (B)(4), INVESTIGATION SUMMARY ==> THE DEVICE ASSOCIATED WITH THIS REPORT WAS NOT RECEIVED FOR EXAMINATION. DEPUY SYNTHES CONSIDERS THE INVESTIGATION CLOSED AT THIS TIME. SHOULD ADDITIONAL INFORMATION BE RECEIVED, THE INFORMATION WILL BE REVIEWED AND THE INVESTIGATION MAY BE RE-OPENED AS NECESSARY. DEVICE HISTORY LOT ==> DHR REVIEW: ¿ PRODUCT CODE 196030300, WORK ORDER 9174298 WAS MANUFACTURED ON 31/MAY/2019. ¿ 12 PARTS WERE MANUFACTURED PER SPECIFICATION AND ALL RAW MATERIALS MET SPECIFICATION. ¿ NO SCRAP ASSOCIATED WITH THIS LOT ¿ NO REPROCESSING ASSOCIATED WITH THIS LOT. ¿ THREE DEVIATIONS FOUND. O NR-0134399 IS ASSOCIATED WITH THIS LOT. THIS WAS RAISED REGARDING CIG2277B GO/NOGO CONDYLE DEPTH GAUGE (METAL-PLASTIC) WHICH FAILED CALIBRATION. NO RISK TO THE PRODUCT WAS DETERMINED. THERE IS NO CORRELATION WITH THE COMPLAINT FAILURE MODE. O NR-0134328 IS ASSOCIATED WITH THIS LOT. THIS WAS RAISED TO FACILITATE THE ISSUE WITH THE PHOTOHELIC GAUGE IN CLEANROOM 5, FEMORAL VALUE STREAM (CIG2906A). THIS WAS FOUND READING LOWER THAN ACTUAL PRESSURE IN THE CLEANROOM MEANING THAT THERE WAS NO RISK THAT THE ROOM COULD BE USED WHERE THERE WAS INSUFFICIENT AIR PRESSURE. THERE IS NO CORRELATION WITH THE COMPLAINT FAILURE MODE. O NR-0139348 IS ASSOCIATED WITH THIS LOT. THIS WAS RAISED TO ADDRESS THE ISSUE WITH VALIDATION DOCUMENTS OF THE DRAG PROCESS IN THE FEMORAL VS. OPERATING PARAMETERS IN DOE (103358763), PQP (103364897) AND OQR (103364556) HAD A TABLE INVERTED FROM THE SUPPLIER RECOMMENDED PARAMETERS. A REVIEW OF PARTS AT THE END OF THE DRAG PROCESS (POST NUTSHELL) WAS UNDERTAKEN TO IDENTIFY IF PARTS GOING THROUGH THE CURRENT PROCESS WERE WITHIN SPECIFICATION. PARTS WERE MEASURED FOR SURFACE ROUGHNESS BY A RA (ROUGHNESS AVERAGE) TESTER AND FOR ALL CTQ (CRITICAL TO QUALITY) FEATURES THROUGH A CMM. THERE WAS NO RISK TO THE PRODUCT AS ALL PARTS PASSED RA AND CMM MEASUREMENTS. THERE IS NO CORRELATION WITH THE COMPLAINT FAILURE MODE. ¿ DUE TO NO SIMILAR FAILURES FOUND IN THE DHR REVIEW, THE ROOT CAUSE OF THE COMPLAINT CANNOT BE DETERMINED. SHOULD FURTHER INFORMATION COME AVAILABLE THAT IMPACTS THE FINDINGS IN THIS INVESTIGATION IT WILL BE REOPENED.

    Additional Manufacturer Narrative · 0

    PRODUCT COMPLAINT # (B)(4). PROVISIONS OF 21 CFR, PART 803. THIS REPORT MAY BE BASED ON INFORMATION WHICH HAS NOT BEEN INVESTIGATED OR VERIFIED PRIOR TO THE REQUIRED REPORTING DATE. THIS REPORT DOES NOT REFLECT A CONCLUSION BY DEPUY SYNTHES JOINT RECONSTRUCTION, OR ITS EMPLOYEES THAT THE REPORT CONSTITUTES AN ADMISSION THAT THE PRODUCT, DEPUY SYNTHES JOINT RECONSTRUCTION, OR ITS EMPLOYEES CAUSED OR CONTRIBUTED TO THE POTENTIAL EVENT DESCRIBED IN THIS REPORT. IF INFORMATION IS OBTAINED THAT WAS NOT AVAILABLE FOR THE INITIAL REPORT, A FOLLOW-UP REPORT WILL BE FILED AS APPROPRIATE.

    Additional Manufacturer Narrative · 1

    (B)(4). IF INFORMATION IS OBTAINED THAT WAS NOT AVAILABLE FOR THE INITIAL MEDWATCH, A FOLLOW-UP MEDWATCH WILL BE FILED AS APPROPRIATE.

    Description of Event or Problem · 1

    IT WAS REPORTED BY THE PATIENT THAT SHE HAD A TOTAL KNEE REPLACEMENT AND SCHEDULED FOR ARTHROSCOPIC SURGERY ON (B)(6), TO SEE OF THERE IS ANYTHING THAT CAN BE DONE TO EASE THE PAIN AND IMPROVE HER RANGE OF MOTION, WHICH IS ONLY 90 DEGREES AND POSSIBLE ALLERGY TO NICKLE. THE CUSTOMER ALSO MENTIONED THAT SHE MADE A CONTACT THROUGH EMAIL ABOUT THREE TIMES BUT RECEIVED NO RESPONSE. DOI: (B)(6) 2019 : DOR: NONE REPORTED (UNK KNEE).

    Devices

    Seq Brand Generic Product Code Manufacturer Model Lot UDI-DI
    1066368 SIGMA CR150 CEM SZ 3 RT SIGMA KNEE PRIMARY : KNEE FEMORAL JWH DEPUY INTERNATIONAL LTD - 8010379 1960-30-300 9174298 10603295074953

    Patients

    Seq Age Sex Outcome Treatment
    1 Required Intervention DEPUY1 GENTAMICIN CEMENT 40G| PFC*SIGMA/OV/DOME PAT 3PEG,35| SIG MOD TIB TRAY CEM COCR 3| SIGMA XLK CVD PLUS INS 3 10MM| DEPUY1 GENTAMICIN CEMENT 40G| PFC*SIGMA/OV/DOME PAT 3PEG,35| SIG MOD TIB TRAY CEM COCR 3| SIGMA XLK CVD PLUS INS 3 10MM